On 3 May 2015, after a five-hour flight, a Cessna 210 aircraft, registered VH-BKD, arrived overhead Broome Airport and extensive fog. After circling for about 45 minutes searching for a break in the fog, the pilot conducted a low-level pass over the runway but was unable to sight the runway or land.
Moments later, the aircraft’s engine surged and spluttered. The pilot quickly changed the fuel selector to the other (left) tank, but the engine did not respond. The pilot conducted a forced landing, and the aircraft struck a dirt mound and slid across a dirt track, coming to rest in mangroves.
The pilot, who was the sole occupant of the aircraft was not injured, however the aircraft was substantially damaged.
The ATSB publication Starved and exhausted: Fuel management aviation accidents has information for pilots about similar incidents and strategies to avoid fuel exhaustion and starvation incidents.
On 3 May 2015, at about 0230 Central Standard Time (CST), a Cessna 210 aircraft, registered VH-BKD (BKD), departed from Alice Springs Airport, Northern Territory for a ferry flight to Broome, Western Australia. The pilot was the sole person on board.
At about 70 NM from Broome, the pilot obtained a weather report from the automated aerodrome weather information service (AWIS) located at Broome Airport. The AWIS indicated a dewpoint of 22 °C and an ambient temperature of 22° C, which indicated conditions suitable for the development of fog.
The pilot reported that the AWIS information prompted them to start considering alternatives should fog prevent a landing. The pilot had planned and flown BKD at the optimum endurance profile of 45% power and changed tanks on a regular time-based pattern. The pilot reviewed the fuel log and determined they had sufficient fuel for a 30-minute search for a suitable break in the fog. If unsuccessful, the pilot planned to turn back inland on a reciprocal to the inbound track and land on the highway.
At about 15 NM from Broome, the pilot observed the start of a thick layer of fog below the aircraft. Arriving overhead Broome Airport at about 0622 Western Standard Time (WST), with the right fuel tank selected, the pilot initially surveyed the area from about 1,000 ft above ground level. However, as there were no breaks in the fog, the pilot descended the aircraft to about 650 ft. The pilot kept the aircraft in visual conditions while circling the airport and Cable Beach areas (Figure 1) occasionally flying at a lower level to take a closer look for possible breaks. With the right fuel tank still selected, the pilot’s search continued for about forty-five minutes.
Source: Google earth annotated by the ATSB
Deciding that landing was not possible until the fog lifted, the pilot sought assistance from the person waiting on the ground for the aircraft. As this person was local and understood the likely extent of the fog, they were able to offer the pilot two alternate airports, as options. The first option, Beagle Bay was about 62 NM to the north, and the second option Eco Beach, about 23 NM to the south. The pilot considered these options, but reasoned that with such widespread fog, these options may also be fog bound. With limited choices and now limited fuel, the pilot turned BKD for one last low-level check along runway 10. The pilot then initiated a climb with the intent of heading back to the highway to land.
Shortly after applying full power to initiate the climb, the aircraft’s engine surged and spluttered. The pilot instantly realised that the right tank had been selected for over an hour, and quickly changed the fuel selector to the left tank. However, the engine did not respond. The pilot then attempted to restart the engine with the ignition key, but reported hearing a crunching noise as the starter motor engaged. The propeller was still windmilling.
With the aircraft only at about 500 ft and descending into the thick layer of fog, the pilot levelled the aircraft’s wings and prepared for a forced landing. Electing to leave the undercarriage retracted, the pilot descended through the fog and noted the outline of a dirt track. The pilot attempted to land on the track, but the aircraft collided with the sandy terrain just prior to reaching it. The aircraft momentum allowed it to skid across the track, coming to rest in the mangroves a few metres on the other side (Figure 2 and 3). The accident site was located within the mangrove area of the Dampier Creek.
The pilot was not injured; however, the aircraft propeller and engine sustained substantial damage.
Source: WA Police
Source: WA Police
Pilot experience and comments
The pilot had around 3,850 flying hours, with around 830 of those on Cessna 210 aircraft.
The pilot elected to conduct the flight at night to increase their night command hours. The evening before the flight, the pilot checked the weather forecast and completed the flight plan. They noted a 30% probability of fog on the terminal area forecast (TAF) for Broome during the planned arrival time. However, the pilot reported that, in their experience, 30% probability of fog would mean non-existent or minimal impact on operations, so they did not consider or plan for any alternates
The pilot pre-flighted the aircraft in the morning prior to the 0230 departure.
The pilot had personal commitments in Broome that morning and back in Alice Springs the next day. Hence, they needed to deliver the aircraft in time to catch the lunchtime jet flight back from Broome to Darwin and eventually be back in Alice Springs the next morning.
The pilot made the following comments about the flight:
- the cruise level was 8,500 ft
- there was smooth conditions enroute but with a stronger headwind than forecast
- the flight time between Alice Springs and Broome was about 5 hours.
The pilot maintained a fuel log during the flight. They initially used fuel from the left tank for 30 minutes, then 60 minutes on the right, back to the left. The pilot continued using this pattern until they arrived overhead Broome.
Although the pilot had calculated there was sufficient fuel to search for a break in the fog for 30 minutes, once pressured and distracted looking for an expected opening to be able to land, the pilot reported flying in excess of 60 minutes with the right fuel tank selected.
The aircraft fuel tanks were dipped post- accident. The right tank had no fuel remaining while there was 45 L remaining in the left tank.
Aviation weather forecasts and alternate aerodrome requirements
The Aeronautical Information Publication Australia (AIP) ENR 1.1 87 details the following requirements concerning planning for alternate aerodromes:
A pilot in command must make provision for flight to an alternate aerodrome, when required, in accordance with the following paragraphs:
…Except when operating an aircraft under the VFR by Day within 50NM of the point of departure, the pilot in command must provide for a suitable alternate aerodrome, when arrival at the destination will be during the currency of, or up to 30 minutes prior to the forecast commencement of, the following weather conditions:
Cloud – more than SCT below the alternate minimum
Visibility – less than the alternate minimum
Visibility – greater than the alternate minimum, but the forecast is endorsed with a percentage probability of fog, mist, dust or any other phenomenon restricting visibility below the alternate minimum….
Note: When weather conditions at the destination are forecast to be as above, but are expected to improve at a specific time, provision for an alternate aerodrome need not be made if sufficient fuel is carried to allow the aircraft to hold until that specified time plus 30 minutes.
AIP GEN 3.5-7 explains that:
PROB% is used in terminal area forecasts (TAF) to indicate an expected 30 or 40% probability of occurrence. If greater than or equal to 50% probability is forecast, reference is made to the phenomenon in the forecast itself not by the addition of a PROB statement
The pilot had planned the flight using maximum endurance performance figures and kept a fuel log. The pilot’s fuel management used a time-based system up until arriving overhead the destination. Due to the unexpected distraction and increased workload of arriving at the destination airport covered in thick fog, with no planned alternates, the pilot lost situational awareness of the aircraft’s fuel state.
Issue number 5 in the ATSB’s Avoidable Accident Series – Starved and exhausted: Fuel management aviation accidents looks in more detail at such scenarios. The report notes that fuel exhaustion is more likely to occur on flights when there is little flight fuel margin.
The Avoidable Accidents series is available on the ATSB website under the Safety Awareness tab.
The ATSB published a research report titled Dangerous Distraction, an examination of aviation accidents and incidents involving pilot distraction in Australia between 1997 and 2004, covers in detail the role of pilot distraction in a number of aircraft accidents.
The research looked closely at 325 occurrences involving some measure of pilot distraction. The researchers were able to develop a taxonomy of three major causes of distraction. They were ‘flight management tasks’, ‘external objects’, and ‘people on board the aircraft’. The report concludes with a number of tentative suggestions for minimising the risk of pilot distraction. Further reading is available on the ATSB website.
Information regarding alternate aerodrome requirements is available in the Air Information Publication (AIP), ENR 1.1-87. This is available on the Airservices Australia website.
The Civil Aviation Safety Authority flight planning kit covers issues such as planning for alternates, obtaining local knowledge when flying to an unfamiliar destination and the importance of considering all aspects of the weather forecast.
This Flight Planning Kit is available from the online shop on the CASA website.
To download, click the link, then right-click and select Save As.
Copyright in material obtained from other agencies, private individuals or organisations, belongs to those agencies, individuals or organisations and should be credited accordingly.
|Date:||03 May 2015||Investigation status:||Completed|
|Time:||0725 WST||Investigation level:||Short - click for an explanation of investigation levels|
|Location:||3 km East Broome Airport|
|State:||Western Australia||Occurrence type:||Fuel starvation|
|Release date:||07 October 2015||Occurrence category:||Accident|
|Report status:||Final||Highest injury level:||None|
|Aircraft manufacturer||Cessna Aircraft Company|
|Type of operation||Private|
|Damage to aircraft||Substantial|
|Departure point||Alice Springs, NT|