Aviation safety investigations & reports

Flight control system event; Boeing 737-700, VH-VBD

Investigation number:
Status: Completed
Investigation completed


Download Final Report
[Download  PDF: 181KB]

At 2108 Eastern Standard Time on 09 August 2005, a Boeing Company 737-700 aircraft, registered VH-VBD, completed a scheduled flight from Melbourne, Victoria to Sydney, NSW. The pilot then reported that the aircraft had 'heavy' flight controls. An inspection by maintenance engineers revealed that the left lower rear elevator cable was incorrectly routed around a stiffener and that the stiffener and cable section had been damaged as a result of contact between them. The aircraft was withdrawn from service for repairs.

In the last week of July 2005, a contract maintenance organisation had replaced eight elevator control cable sections during a scheduled heavy aircraft maintenance check. The cables were replaced to comply with Boeing Company service bulletin 737-27-1254 revision 1.

While preparing the rear elevator control cables for removal, a cable end was not secured at the lower left rear elevator input quadrant, before removing the cable keeper. When the cable keeper was removed, the unsecured cable section slipped from sight. While recovering the cable, it was inadvertently misrouted around a fuselage stiffener. When the new cable was pulled into place it followed the same incorrect route around the stiffener.  This resulted in contact between the cable and the stiffener.

As a result of the occurrence, the contract maintenance organisation implemented a number of changes to improve maintenance planning and documentation.

Download Final Report
[Download  PDF: 181KB]
General details
Date: 09 August 2005   Investigation status: Completed  
Time: 21:08    
Location   (show map): Sydney Aerodrome    
State: New South Wales   Occurrence type: Control - Other  
Release date: 05 February 2007   Occurrence category: Incident  
Report status: Final   Highest injury level: None  

Aircraft details

Aircraft details
Aircraft manufacturer The Boeing Company  
Aircraft model 737  
Aircraft registration VH-VBD  
Type of operation Air Transport High Capacity  
Damage to aircraft Nil  
Departure point Melbourne, VIC  
Destination Sydney, NSW  
Last update 16 February 2016