Jump to Content
Download Final Report
[ Download PDF: 12KB]
 
 
 
At Sydney, the aircraft had been released for service, prior to departure for Bangkok, with the number three engine fire detection 'B' loop inoperative, in accordance with the provisions of the minimum equipment list. The remaining 'A' loop would be used for fire detection and warning for the engine. The aircraft operated normally to Bangkok, where a transit service was performed before the next sector to Rome. The subsequent takeoff was rejected at 140 knots when the fire warning for number three engine activated. The aircraft returned to the gate where eleven of the sixteen mainwheels deflated due to overheating. The mainwheels were changed. Rectification of the fire warning problem consisted of repairing a broken wire at the 'B' fire detection loop connector, adjacent to number three engine starter motor. Both 'A' and 'B' loops then tested normally. As the aircraft was rotated during the next takeoff the number three engine fire warning activated again. The crew carried out the fire warning actions and shut down the engine. Fuel was jettisoned to bring the aircraft to maximum landing weight, prior to returning to Bangkok. An inspection of the engine revealed two holes burnt in the combustion case adjacent to the fire detection loops. The holes allowed hot gasses to escape and activate the fire warning system. Investigation of the incident by the operator has resulted in a change to company procedures. Any rectification for a fire warning defect will now require a ten minute minimum high power ground run to verify the integrity of the engine. In addition, the inspection intervals for combustion cases have also been reduced.
Download Final Report
[ Download PDF: 12KB]
 
 
 
 
General details
Date: 08 March 1997 Investigation status: Completed 
Time: 8:24 UTC Investigation type: Occurrence Investigation 
 Occurrence type:Rejected take-off 
Release date: 21 April 1997 Occurrence category: Incident 
Report status: Final  
 
Aircraft details
Aircraft manufacturer: The Boeing Company 
Aircraft model: 747-338 
Aircraft registration: VH-EBV 
Sector: Jet 
Damage to aircraft: Minor 
Departure point:Bangkok, Thailand
Destination:Rome, Italy
 
 
 
Share this page Provide feedback on this investigation
Last update 28 October 2014